Westerbeke 12.0KW - 50Hz EDT Installation Manual Page 7
- Page / 66
- Table of contents
- TROUBLESHOOTING
- BOOKMARKS
Rated. / 5. Based on customer reviews
TABLE
OF
CONTENTS
Parts
Identification
.
............................................
2
Fuel
Injectors
....................................................
28
Introduction
.......
..................................................
3
Injector Testing ............................................ 28
Warranty Procedures ......................................
3
Spray Pattern ............................................... 28
Serial Number Location ...............................
.4
Fuel
Injection
Timing
........................................
28
Diesel
Fuel,
Engine
Oil
and
Coolant.
..................
5
Preparation ................................................... 28
Digital
Control
PaneL
.........................................
6
Inspection ..................................................... 28
Internal Components .....................................
7
Adjustment ................................................... 28
Remote
Stop/Start
PaneL
.............................. 8
Glow
Plugs
...........
~
.............................................
29
Preparations
for
Initial
Start·Up
.........................
9
Starter
Motor
.
....................................................
30
Pre-Start
Inspection ....................................... 9
Emergency Start ..........................................
31
Generator Voltage .......................................... 9
Service .........................................................
31
Generator
Break·ln
Procedure
..........................
10
Alternator
Testing
...
..........................................
32
The
Daily
Operation
..............
.............................
10
Voltage Regulator ....................................... .32
Safety
Shutdown
Switches
................................
11
Checking the Service Battery ...................... 34
High Exhaust Temperature Switch .............
.1
1
Battery Care .................................................
34
DC
Circuit Breaker ......................................
11
W
"
D'
Iring
lagram
..................................................
35
Oil Pressure Sensor ......................................
11
Wiring
Diagram
(24
Volt)
..................................
36
Coolant Temperature Sensor .......................
11
Generator
Information
..
....................................
.37
Break·
In
Procedure/Daily
Operation
......
.......
11
a
BT
Generator
.....................................................
38
Maintenance
Schedule
.....................................
12
Six
and
Twelve
Stud
Illustrations
.....................
38
Cooling
System
.................................................
. 14
BT
Generator/Single
Phase
(6
Stud)
.................
39
Changing Coolant ........................................ 14
Internal
Wiring
Diagram
....................................
39
Thermostat ...................................................
15
Generator
Voltage
Adjustment
........................
.40
Raw Water Cooling Pump ........................... 15
Six Stud Voltage Connections ....................
.40
Changing the Raw Water Impeller .............. 16
No Load Voltage Adjustment .....................
.41
Heat Exchanger ........................................... 16 Full Load Voltage Adjustment. ....................
41
Air
Intake/Silencer
............................................
17
A VR - Six Stud ............................................
42
Fuel
System
.......................................................
18
Shore
Power
Connections
.................................
42
Fuel LiftlWater Separator ............................ 18
BT
Generator
AVR
(Three
Phase)
......................
43
Fuel Lift Pump ............................................. 18
BT
Generator
(Three
Phase)
Fuel
Lift
Pump Filter ................................... 18
Internal
Wiring
Diagram
...................................
.44
Fuel Filter ....................................................
18
Regulator
Sensing
Three
Phase
.........
..............
.45
Engine
Lubricating
Oil
....................................... 19
Internal
Wiring
Diagram
(12
Stud)
....................
46
Engine Oil Change ...................................... 19
BT
Generator
Troubleshooting
Chart
...............
.47
Oil
Pressure
..
.....................................................
20
Specifications
(3
Cylinder
Engine)
...................
.48
Testing Oil Pressure .....................................
20
8.0/6.0Kw
-10.0n.5Kw
....................................
49
Remote
Oil
Filter
...............................................
21
11.5/9.2Kw
-
12.6/1
0.4Kw
................................
50
Fuel LiftlWater Separator ............................ 21
Specifications
(4
Cylinder
Engine)
....................
51
Engine
Troubleshooting
(Chart)
........................
22
12.5/9.4Kw
.
15.0/12.0Kw
................................
52
Engine
Adjustments
...........................................
24
Lay·Up
and
RecommiSSioning
...........................
53
Drive Belt Adjustment ................................. 24
Power
Take·Off
..................................................
55
Electronic Governor .................................... 24
Raw
Water
Discharge
Hose
...............................
56
Valve Clearance ........................................... 25
Metric
Conversion
Data
....................................
57
Testing Engine Compression ....................... 26
Suggested
Spare
Parts
......................................
58
Fuel Injectors ...............................................
26
Engines & Generators
1
- OPERATORS 1
- CALIFORNIA 2
- PROPOSITION 2
- WARNING 2
- WARNING: 2
- INSTRUCTIONS 3
- Engines & Generators 4
- INSTALLATION 6
- CONTENTS 7
- INTRODUCTION 9
- #43400 provides detailed 10
- ~OOLANT 11
- DIGITAL 12
- CONTROL 12
- ~'.5~ 14
- OIPSTICK~ 15
- \\~PPROXIMATELY 15
- PROCEDURE 16
- STARTING 16
- SHUTDOWN 17
- SWITCHES 17
- BREAK-IN 18
- PROCEDURE/DAILY 18
- OPERATION 18
- MAINTENANCE 19
- SCHEDULE 19
- 10 disconnect the DC power 20
- COOLING 21
- ~COOlANT 22
- SILENCER 24
- Changing/cleaning 25
- LUBRICATING 26
- PRESSURE 27
- (OPTIONAL) 28
- TROUBLESHOOTING 29
- CYLINDER 32
- ADJUSTMENTS 33
- INJECTOR 33
- INJECTORS 34
- ~~I:lt~ 35
- DESCRIPTION 36
- INSPECTION 36
- TESTING 36
- STARTER 37
- (I~'s) 39
- ,"/ 40
- ALTERNATORS 41
- TESTINGJTROUBLESHOOTING 41
- & Generators 42
- GENERATOR 44
- INFORMATION 44
- 1.:!:.!_aS(J! 46
- PfiiL-J 47
- VOLTAGE 48
- ADJUSTMENT 48
- <-ir 49
- Stability 50
- INTERNAL 51
- Description 52
- ,.----11 53
- D 3 Transformer 54
- + 5 - a 55
- Hertz (.60%) 56
- 12.6KW - 60 57
- 10.4KW - 50 Hertz 57
- RECOMMISSIONING 60
- SYSTEMS 62
- DISCHARGE 63
- Pounds~Force 64
- (in~lb) 64
- REVrSED 66
Related products and manuals for Power generators Westerbeke 12.0KW - 50Hz EDT
(53 pages)© 2020, manymanuals.com. All rights reserved. | 1.063 s |
Manymanuals.com
Manymanuals.de
Manymanuals.fr
Manymanuals.it
Manymanuals.pl
Manymanuals.cz
Manymanuals.es
Manymanuals-pt.com
Comments to this Manuals